View Single Post
      06-18-2010, 10:25 AM   #1
Daniel135i
Banned
Italy
52
Rep
524
Posts

Drives: 2011 135i 6M, AW, CR, MSPORT
Join Date: Jun 2010
Location: USAF Aviano Italy

iTrader: (0)

Garage List
2011 135i  [10.00]
2005 SRT-4  [7.00]
My other ride...

IDLE VIDEO...


Video - SRT-4 Dyno, 478 whp on C16 @ 23 psi. Not the last of the day....

419whp @19psi pump gas

Video - 481whp 447tq @ 28 psi C16.

Video - 451whp @ 21 PSI 93 Octane

Video - DanSRT-4 dyno vid

Video - Last pump run screen shot, 450whp/409..tq.

~ENGINE MODS~
-TKMotorsports Race Head -
5-Axis CNC Ported Intake & Exhaust Ports
CNC Combustion Chambers
Oversized Valves (36mm (+1mm) Race Intake Valves and 30.5mm (+2mm) Race Exhaust Valves)
Manganese Bronze Guides
SERDI Proprietary “Competition” Valve Job
Diamond-Honed Valve Guides
Oversized Valves (36mm (+1mm) Race Intake Valves and 30.5mm (+2mm) Race Exhaust Valves)
Brian Crower Valve Springs w/Tit. Retainers
‘Single Groove’ Valve Keepers
Viton Valve Seals
Deck Surface Skimmed .003”
Jet-Wash Clean
Flow bench tested
SRT-4 Brian Crower Stage 3 Cams - adv. dur-272°/272°-dur@.050-194°/186°-Lift .389"/.383"
Fidanza Cam Gears
Flow #s
Intake (Solid 30-50 cfm Gains from stock) .300 280 .400 305
Exhaust (Over 50 cfm Gains from stock)
.300 225
.400 230
-TKMotorsports Bottom End-
TKMS 5 Layer Head Gasket
Engine Block Bored .020
Knife edged Crank / Balanced
SRT-4 Wiseco Pistons 8.8:1
SRT-4 Wiseco Piston Rings
Brian Crower Pro Series Rods
TKMS Crank Strap Kit
TKMS headstud Kit
STANDALONE AEM EUGO ENGINE MANAGEMENT SYSTEM
AGP Dual Ball Bearing 50 Trim turbo kit, including:
76 trim T31 / .63 A/R DBB 50mm T3/T4 turbo
Turbonetics 35mm Evolution wategate
Wastegate dump Tube
Boomba Teflon Intake Mani gasket
AGP cast tubular exhaust manifold
Full ceramic and polish on all of the above
Form&Function Ported / Polished 60mm Intake Manifold
Kinetic Motorsports 60mm Throttle Body
AGP turbo heat shield
TKMotorsports Coil Pack Heat Shield
AGP upper intercooler hard pipe with HKS flange
AGP lower intercooler hard pipe
HKS Super Sequential Blow Off Valve
AGP RACE Front Mount Intercooler
AGP 3in Cold Air Intake (lower pipe removed)
AEM Dry Flow Intake Filter
AGP solid motor mounts upper and lower
AGP solid Tranny mount
NGK Iridium spark plugs
Magnacore 8.5 Plug Wires
Custom made Oil Catch Can / Drain valve
180 degree Thermostat

~FUEL SYSTEM~
Aeromotive Fuel Press Regulator
AGP Returnless fuel line kit
750cc injectors
TKMotorsports Modified Walboro 255 Fuel Pump
TKMotorsports Fuel Restriction Mod

~EXHAUST SYSTEM~
Billy Boat 3in full turbo back exhaust including:
Resonator pipe (Cat delete section)
3in O2 housing


~DRIVE TRAIN~
ACT 6 puck Unsprung race/road clutch
XACT flywheel
Saftey wired flywheel bolts to prevent backout

~ELECTRONICS~
AEM EUGO STAND ALONE EMS
Defi "Blue Racer" gauges:
-Oil Press
-Oil Temp
-EGT
-Boost

~SUSPENSION & HANDLING~
Tein SS fully adjustable track ready Coilovers
Centerline RPM 19X8 in Ultra Lightweight Aluminum alloys (only 19 lbs CHROMED!)
General Tire UHP Exclaim High Performance Y speed rated (and Highest traction rating possible)
B-Woody Front End "H" Brace
RevItUp traction bars
DC Sports Front Strut Bar
DC Sports Rear Strut Bar
Stock ACR front / rear sway bars
Energy Suspension front end links
Energy Suspension rear end links
Sway bar Energy Suspension poly bushings
BFG D.R. on 15 inch PT Cruiser Steel wheels
MH Slicks 26x8.5x15in on PT Cruiser Steel wheels

~BRAKES SYSTEM~
WilWood Dynalite Front 4 Piston Calipers with 12.19" Drilled Rotors
Mopar 2 Piston Rear Calipers with Power Slot Slotted/Drilled Rotors
Hawk Performance Composite Pads all 4 corners
Stop Tech Stainless Steel Braided brake lines
Motul Brake Fluid

~Interior Mods~
Maddog custom Short throw shifter 58% throw reduction
Corbeau CR1 passenger / driver seats
Custom made floor mats
MOMO Shift Knob
MOMO Shift Bootie
MOMO Pedal Set
MOMO Parking Brake Handle
MOMO Parking Brake Bootie

~Exterior Aesthetics~
Redline QuickLIFT hood strut dampeners
Folia Tec Aluminum shorty antenna
Color Matched painted side view mirrors
Sylvania 9007SL Silverstar headlight bulbs
Titanium colored Front Blinkers
Clear Side Marker Lenses
Yellow Led Side Markers
Hyper Blue Fog Lights





























Last edited by Daniel135i; 06-20-2010 at 09:27 AM..
Appreciate 0