|
|
|
07-16-2012, 01:37 PM | #1 |
Captain
81
Rep 655
Posts |
FAQ: BMW eLSD - Not your dad's open diff!
I'd like to dis-spell some rumors and clear up some misconceptions regarding BMWs electronically controlled differential or as some call it the "electronic LSD".
The BMW 1-series as well as many other recent BMW models feature an electronically controlled Automatic Differential Brake (ADB) system, that in conjunction with a normal open rear differential works to emulate a traditional mechanical limited slip system. Below are some questions I've compiled based on forum posts I've found here. Feel free to ask more questions and I'll update this FAQ periodically. All these answers are from my personal experience and to the best of my knowledge. I reserve the right to make corrections as better information becomes available. ---- Does the 1-series (or other recent BMWs) have an open rear differential? Mechanically, the answer is yes - there is a completely open rear differential between the two rear wheels. This open diff is however assisted by an automatic differential braking system that will apply resistance to one wheel to equalize traction between the two wheels. What does that look like in action? Here's a graph showing the on-board telemetry of a 135i during an autocross run going around a left hand corner: The light blue line shows braking force applied to the left (inside) rear wheel and the yellow line shows braking force applied to the right (outside) rear wheel. Dark blue shows the throttle pedal position and the red line show the brake pedal. As you can see, without any brake pedal applied, the car applies some light brake pressure to the inside (less loaded) rear wheel to prevent wheel spin. Also note that when the brake pedal *is* actually pressed, the car still manages the left/right brake balance to keep the car as neutral as possible under braking. This car was equipped with a mechanical LSD as well - so even with a mechanical LSD, the system still provides additional inputs. If I loose traction, will only 1 wheel spin? No. The system automatically applies brake pressure to the wheel with the least amount of traction to get both wheels spinning. Does the system reduce engine power? No. Brake pressure is applied to one wheel, the engine power is not affected. Will the braking force lock up the wheel or slow me down? No. Only light brake pressure is applied to the spinning wheel this does not slow the car down. Mechanical limited slip differentials perform the exact same function, though instead of using the brakes to apply friction on the spinning wheel, mechanical friction is applied inside the differential. Does this system interfere even if I'm not smoking tires? Yes. The electronic differential braking acts even if you're not lighting up tires to help stabilize the car in a variety of situations. Can I turn this system off? No. Even with all traction and stability control (DTC and DSC) turned off, differential braking is still enabled. Can I drift with the only the electronic differential? Yes, absolutely! Do I still need a mechanical LSD then? Maybe. This is a tough question to answer and a personal one at that. The electronically assisted differential works rather well actually. It puts power down to both wheels, allows drifting and generally provides a positive driving feedback and control. However, the electronic system has it's limits. Once traction loss is too great, the system can be overwhelmed, causing a more sudden loss in traction than what a mechanical differential would do. In other words, you might spin more suddenly than with a mechanical diff. Also, the electronic control does not provide the same feedback to the driver and the same confidence that a mechanical differential does. Thus controlling the car is more difficult than it would be with a mechanical diff. Ultimately, there is no huge difference in traction availability between the mechanical and electronic differentials. The biggest difference is in the way the car "feels". This is mostly evident exiting corners under heavy throttle. This is where the mechanical differential shines. Because the differential system uses your brakes to aid traction, excessive heat and wear may be generated on your rear brakes during track driving. A mechanical LSD can help reduce this. Do I need a mechanical LSD for.... ... daily driving? No. ... "spirited" canyon driving? No. If you're regularly overwhelming the electronic differential on public roads, please start autocrossing or track driving your car instead. ... drag racing? Maybe. The electronic differential is very good providing straight line traction. A mechanical LSD is likely not going to make a big difference here. On the highest levels of the sport, maybe an LSD would make a difference. At that point you may be better off with a locking one instead though. ... track/autocross? Maybe. BMW's differential braking system works rather well even for autocrossing or track driving. Don't be afraid to track/autocross your car in stock trim. A mechanical differential will make a big difference in controllability and confidence here so there is a definite benefit for track junkies and autocrossers. ... drifting events? Most likely. More control = better drifts. --- Revisions: 2012-07-16 Added comment on brakes 2012-07-18 Removed friction comparison statement Last edited by int2str; 07-18-2012 at 04:59 PM.. |
07-16-2012, 01:50 PM | #2 |
Resident Kerbalnaut
479
Rep 10,703
Posts |
The problem with the eLSD - or at least my problem with it - is thats its a reactionary system. Despite how sensitive the sensors are or how quickly and accurately the rear brakes can be applied it still takes time.
The eLSD also changes the handling balance of the car by applying braking force to slow a wheel rather than clutch friction on a shaft. Using the eLSD vs not using it will result in a different attitude (ie roll or squat angle) for both cases. It all makes a difference. |
Appreciate
0
|
07-16-2012, 01:54 PM | #3 |
Major General
4457
Rep 9,160
Posts |
Yep, nearly worthless system. When running the Ortega Hwy, Mullholland or GMR, the 1er was constantly roasting the inside tire, something my M Coupe with an honest to god LSD rarely did, even with an E30 rear suspension and a much shorter wheelbase.
|
Appreciate
0
|
07-16-2012, 01:55 PM | #4 | |||
Captain
81
Rep 655
Posts |
Quote:
Quote:
The bigger difference come from how much friction (and when) is applied. Quote:
Also note that you do not have an option of "not using" eLSD. |
|||
Appreciate
0
|
07-16-2012, 01:58 PM | #5 | |
Captain
81
Rep 655
Posts |
This is not very helpful and misleading.
Please back up statements like this with better data. Quote:
|
|
Appreciate
0
|
07-16-2012, 02:15 PM | #6 |
Major General
4457
Rep 9,160
Posts |
I've done plenty of track days, thanks. I'll continue to do them, in cars with LSD's, not my wife's 1er, it's just not much fun and between the lack of a mechanical LSD and the copious factory understeer, I just don't enjoy tracking the 1er.
I think the eLSD is severely lacking in the manner in which it allows power delivery. The combination of throttle lag in the N54 (the N55's I've driven seem worse) and the lack of an actual LSD make for an unsteady and unpredictable power delivery. I'd actually be curious to drive a 128i hard to see how much of my dislike of the eLSD is perhaps related to the turbo engine. I did mistakenly say inside tire, when I should have said outside tire, entirely my mistake. In my opinion the 135i is a hot mess of handling that is further hindered by the eLSD. An E9x is noticeably better sorted, but still exhibits lots of the same weaknesses from the eLSD, but at least the suspension is better tuned towards neutrality. The 1M and M3 completely fix the suspension issues and magically rock an actual LSD too. |
Appreciate
0
|
07-16-2012, 02:26 PM | #7 |
!
742
Rep 3,267
Posts |
Any idea if the 128i has the e-diff or not? I've read some press releases that seem to imply that it is only included on the 135i (along with more sport-oriented traction control logic, maybe?), but I haven't come up with anything definitive.
__________________
____________________________ |
Appreciate
0
|
07-16-2012, 02:39 PM | #8 |
Let's save military ranks for those who earn it!
45
Rep 1,161
Posts
Drives: ...on the Ragged Edge
Join Date: Dec 2008
Location: Edmonton, AB, Canada
|
The eDiff can put you into a spin if you ride the speed curbing through a series of esses. Basically, it can cause a wheel which is momentarily in the air to land with the brake fully applied, which results in a nasty surprise.
A very experienced fellow BMW instructor nearly took his car into the wall at Calgary's Race City Speedway like that. The car was on R-compound tires (higher grip levels than street tires), which of course contributed somewhat, but the system is not flawless. A proper Torsen LSD won't put you off track backwards with one locked wheel, nor will it see you wear out your rear brake pads faster than your fronts. While a decent system, it's not by any means a replacement for a proper mechanical (clutch or geared) limited slip differential. I also find that the eDiff is pretty useless in winter conditions.
__________________
Richard
2013 BMW M3 Individual -- Fire Orange (sold) 2013 BMW X1 xDrive35i M-Sport -- Valencia Orange (sold) 2011 BMW 1-series M Coupe (#205/220) -- Valencia Orange (sold) 2009 BMW 135i M-Sport Coupe -- Space Grey (sold) Last edited by ZIPNBYE; 06-24-2015 at 03:26 PM.. |
Appreciate
1
|
07-16-2012, 02:42 PM | #9 |
Banned
73
Rep 2,070
Posts |
"Any idea if the 128i has the e-diff or not? I've read some press releases that seem to imply that it is only included on the 135i (along with more sport-oriented traction control logic, maybe?), but I haven't come up with anything definitive."
_____________________________________ The 128 also has the system. Dont have any proof at hand but have read so from reliable sources. Someone will confirm, Im sure. |
Appreciate
0
|
07-16-2012, 03:10 PM | #10 | |||
Resident Kerbalnaut
479
Rep 10,703
Posts |
Quote:
Quote:
The force applied by an LSD is centered on the halfshaft. Braking pressure is not centered on the shaft. This creates a positive moment on the entire system - a moment that isnt matched on the opposite side of the but why would you want your suspension to absorb a force that it doesnt need to?car. One that is more than likely fully absorbed by the suspension, granted. That brings me to your final point. You can PM if you want more details on any of these principals. But like I said. Its not just a force - but where and how you apply that force on a system that makes all the difference. Quote:
Im fully aware of how the car ive owned for four years and put 75 miles on functions mechanically. By braking a wheel youre effectively changing the brake bias of the car - bringing it more to the rear and to a corner. Changing the way the car loads the suspension which changes the center of gravity in a corner. If you want to experience it first hand, albeit in an extreme case, go find someone with an ActiveE (If you were local id let you try it on mine) and let the energy recover system kick in on a fast and tight turn. and note the way that the corning behaviour of the car changes relative to you having a balanced throttle. Through personal experience I can tell you that the eLSD is a very jerky system - infact when its on at full bore you can hear it pulsating similar to an ABS system - next time youre at an autox pay attention for the sounds. In a slide you constantly have to correct for that pulsing - leading to a lot of work that you simply dont need to do. A mechanical LSD is more smooth and progressive - its just a better way of doing it from the standpoint of driving dynamics. Like I said earlier. PM me if you want some more clarification. Also sorry if my words are muddled a bit. I woke up at 4am today to drive from Boston to NYC and went straight into my job after a very busy and tiring weekend. |
|||
Appreciate
1
Bimmer TV125.00 |
07-16-2012, 03:23 PM | #11 | |||
Captain
81
Rep 655
Posts |
Quote:
As far as I can tell, all recent BMWs have adaptive differential braking, including the 128i. Quote:
I'd still maintain that they are largely the same for most drivers, controllability and "feel" aside. Quote:
|
|||
Appreciate
0
|
07-16-2012, 03:28 PM | #12 | |
Captain
81
Rep 655
Posts |
Quote:
|
|
Appreciate
0
|
07-16-2012, 03:30 PM | #13 | |
Resident Kerbalnaut
479
Rep 10,703
Posts |
Quote:
But those on this site typically arent considered "most drivers" and value things like driving dynamics and controlability. Maybe they fixed it on the newer systems. But back in 2008 and 2009 it was a very noticeable and jerky system. Then again I refuse to update my SW - the new versions are terrible engine-wise. |
|
Appreciate
0
|
07-16-2012, 03:37 PM | #14 | |
Major General
4457
Rep 9,160
Posts |
Quote:
Yet it remains that the only good thing the eDiff has over a realDiff is that the eDiff is cheaper for BMW. |
|
Appreciate
0
|
07-16-2012, 04:06 PM | #15 |
Loves his G20
265
Rep 2,507
Posts |
I don't track my car so I think the eLSD is a great feature.
__________________
2020 330ix-Msport Past- 2013 135i 2011 135i |
Appreciate
0
|
07-16-2012, 05:14 PM | #16 |
Brigadier General
504
Rep 3,445
Posts |
Great information, especially with respect to efficiency. Perhaps all the moaning about mechanical LSD should stop, but it won't.
__________________
See my photography at http://ronscubadiver.wordpress.com
|
Appreciate
0
|
07-16-2012, 06:07 PM | #17 |
Resident Kerbalnaut
479
Rep 10,703
Posts |
It's not moaning when it's science.
|
Appreciate
0
|
07-16-2012, 07:05 PM | #18 |
Lieutenant
39
Rep 529
Posts |
OP, why are you such a big supporter of the eLSD? It doesn't work. Plain and simple. I think I have seen you post up autoX videos, never road course. Besides the fact that the higher the speed the less effective it will be, it cooks your brakes. I'd much rather have my brakes in better shape than the supposed traction it gives you. Every single corner that requires finesse with the go pedal, one of the tires gives up before the car will get sideways. At low speeds when you know the rear is going to step out, the car is so unpredictable. It steps out, the brakes come in, you lose some angle, it gains the angle back, and so on until the car grabs.
We haven't even gotten into the effects under braking and turn in.
__________________
KW V3's, Sparco Pro2000's, Vorshlag CP's, JB4, Heat Wrapped Raceland DP's, aFe stg. 2 Sealed Intake, Miro 111's, Hankook RS3's 225/245 (for now), Seibon M3 CF Hood, Turner Motorsports Alum. Radiator, Big Tom IC, BMW Performance bumper.
|
Appreciate
0
|
07-16-2012, 07:05 PM | #19 |
Lieutenant
39
Rep 529
Posts |
Great explanations in here man.
__________________
KW V3's, Sparco Pro2000's, Vorshlag CP's, JB4, Heat Wrapped Raceland DP's, aFe stg. 2 Sealed Intake, Miro 111's, Hankook RS3's 225/245 (for now), Seibon M3 CF Hood, Turner Motorsports Alum. Radiator, Big Tom IC, BMW Performance bumper.
|
Appreciate
0
|
07-16-2012, 07:19 PM | #20 | ||||
Captain
81
Rep 655
Posts |
What makes you think I'm a "supporter"? Hint - my car has a limited slip.
I'm simply trying to refute some misconceptions and overall misinformation that's being proposed throughout various posts on this forum. Quote:
Quote:
I'll simply ask a question: Have you driven a semi-powerful (let's say 150hp+) BMW with an actual open diff on track before? Quote:
You must think that a digital feedback loop is measured in minutes, not microseconds. Quote:
|
||||
Appreciate
0
|
07-16-2012, 08:29 PM | #21 | |
Lieutenant
39
Rep 529
Posts |
Quote:
__________________
KW V3's, Sparco Pro2000's, Vorshlag CP's, JB4, Heat Wrapped Raceland DP's, aFe stg. 2 Sealed Intake, Miro 111's, Hankook RS3's 225/245 (for now), Seibon M3 CF Hood, Turner Motorsports Alum. Radiator, Big Tom IC, BMW Performance bumper.
|
|
Appreciate
0
|
07-16-2012, 09:37 PM | #22 | |
Captain
81
Rep 655
Posts |
Quote:
I recently drove an older, open diff 528i again and the difference to even a stock 135i is shocking. I would find it hard to believe that the difference isn't obvious. With a completely open diff, the inside wheel lights up like a Christmas tree around pretty much every corner. |
|
Appreciate
0
|
Post Reply |
Bookmarks |
Thread Tools | Search this Thread |
|
|