|
|
|
05-01-2009, 09:08 AM | #1 |
Captain
112
Rep 810
Posts |
Cracked Windshield
Was washing my car this morning, and I forgot to put the wipers down before popping the hood. The hood forced the wiper into the windshield and put some serious cracks in it. Time for a replacement! The paint on the hood is also chipped off right on the rim of the hood, but I'm not too upset about that. I just hope it won't take too long to get it replaced because it is spreading!! Everyone, please be careful - this is a very easy mistake to make!!
|
05-01-2009, 09:56 AM | #3 |
Captain
32
Rep 683
Posts
Drives: "Bianca" 135cic AW/TC
Join Date: Dec 2008
Location: FLL
|
In a warm weather environment, I would NEVER have thought this to happen. I paid attention up north, because the cold makes the glass more brittle.
But still, the wiper is rubber, and just the shock of rubber hitting the glass can make it spread, and then in warm weather it can spread that quick. That is crazy. Call your insurance company. If the crack is less than 12", you can have it resin-filled for free, and your insurance company won't hit you for the claim. Once over that, you will easily go over the $1500 line for how insurance companies will raise your rates on a claim that much or higher. If you have USAA, they have a nice benefit of that you can replace once every two years with no rate hikes if it is damaged. I don't know about other companies. Oh, and the resin is clear, the crack goes away. You can barely see it.
__________________
2008 135cic, Alpine White/Terracotta Leather/BlackTop, Premium Package (Bluetooth, folding mirrors, etc), Sport Package with M Wheel, Navigation, Logic7 with HD and IPod and Sirius, Steptronic, M Aerodynamic Kit
2001 Focus ZX3, modified for fun commuting Previous 2006 325xi 2002 Audi A4 3.0 Quattro 1997 Audi A4 2.8 Quattro 1984 Audi 4000S Quattro modified 1955 Ford Thunderbird 1969 Camaro modified 1993 Ford Explorer (basic hauling) 1984+1988 Ford Broncos 1993 Honda Civic (Commuter, junk) 2008 Mini (wife's car, AWESOME) A few more |
Appreciate
0
|
05-01-2009, 10:18 AM | #4 |
Captain
22
Rep 774
Posts |
It is a Comprehensive Claim and there will be no surcharges..I have USAA and they are the best. Just call their toll free number, and do not use who they recommend..Safelite is terrible. If you know a good glass shop tell them you want to take it there. It will be as good as new. Forget the resin fill, it will drive you nuts every time you look at it.
|
Appreciate
0
|
05-01-2009, 10:47 AM | #5 |
Major General
124
Rep 5,626
Posts |
There is a warning in the manual on page 121 - but it needs to be much more prominent. Ditto with raising the front windows first in the 'vert.
Tom |
Appreciate
0
|
05-01-2009, 11:01 AM | #6 |
Captain
112
Rep 810
Posts |
Well, it's not actually the rubber that is cracking people's windshields. It's the metal piece that attaches to the motor. When you lift the hood up, it forces the bottom of the metal piece into the glass. The rubber is harmless. They got that right!
|
Appreciate
0
|
05-01-2009, 12:52 PM | #7 |
Lieutenant General
4986
Rep 10,210
Posts
Drives: 2024 Golf R / 718 SRS (on way)
Join Date: Sep 2006
Location: Dallas, TX
|
I had a small crack, from a rock I think, that started in the left hand corner of my windshield, unrelated I know to the OP's experience, but still....I think the glass is very soft and is prone to cracking.
The crack now goes all the way across the windshield, and I obviously have to replace the whole thing. Call the dealer, and guess how much? $1,431.19!!!!! How can a windshield replacement be nearly 4% of the total cost of the car? I nearly fell over when they told me that....and I know other people with BMWs, and almost all of them have a little crack or divot in their windshields....I just think this is not a small issue.....and now I am going to have to fork over nearly 1500 bucks!!! Maybe the gurus in Munich need to address the glass composition.....sigh.....
__________________
Past rides: 2022 718 Spyder, 2022 MINI JCW, 2016 981 BGTS, 2020 MINI JCW, 2017 F80, 2015 981 CS, 2014 F22 235, 2011 E82 135, 2008 E82 135, 2007 E92 328, 2007 E92 328 (My lady drives an OG M2. So does my dad)
|
Appreciate
0
|
05-01-2009, 01:59 PM | #9 | |
Proud 1er
24
Rep 699
Posts |
Quote:
I believe some people have reported that if you let the wiper drop on it's own it can crack the windshield wiper also. You need to guide it back down. I really doubt there is anything wrong with BMW glass. I don't buy that claim that it's soft or anything like that. It's part of the structure and it also has to hold up to debris at autobahn speeds. Unfortunately the design of the 135 just makes this a problem. But with any auto glass if you push something sharp into it with enough force it will break. |
|
Appreciate
0
|
05-01-2009, 02:34 PM | #10 |
Captain
22
Rep 774
Posts |
The glass is not soft...it is a special piece of laminated safety glass. BMW glass is no different that what they use on Porsche, Ford, Hummer...
To the person that said they have to pay 1500...do you not have comprehensive coverage? If so, you only pay your deductable. Safelite sucks. They will hire anyone, and only interested in getting it done as fast and as cheap as possible. They damamged my hood with dent and scratches on time, and the front of my roof another time. Use someone else if you can. |
Appreciate
0
|
05-01-2009, 02:45 PM | #11 |
likes boobies ( o )( o )
13
Rep 275
Posts |
can you take a picture of it? if it doesn't have a clear point of impact it maybe covered under warranty. there is a service bulletin about cracking windshields...
SIB513508 SUBJECT Cracked or Damaged Windshields MODEL All models SITUATION The windshield may become cracked or damaged for a variety of reasons. While the windshield requires repair or replacement, it is important to take note of the following guidelines regarding what types of damage may or may not be covered by the BMW New Vehicle Warranty. CAUSE Windshield damage is typically caused by one of the following: Outside influence – typically stone chips in nearly all cases Excessive force applied – such as levering out the A-pillar trim Stress crack – due to heavy torsional loads on the vehicle's body or an incorrectly-fitted windshield (least common cause) PROCEDURE When evaluating a cracked or damaged windshield to determine whether it is eligible to be claimed under warranty, it is necessary to determine the root cause of the damage. Reviewing the following possible causes will help to determine the root cause. Outside Influence An outside influence is responsible for the damage if: One or more chips are present on the outside of the glass along the crack; A crack started from anywhere other than an outside edge. Run a non-permanent felt tip pen or small marker over the length of the damaged area. Even very minor surface damage will be felt. Often when a small stone chip occurs, the subsequent crack takes time to develop, as the vehicle is subject to normal torsional loads or temperature fluctuations. Any damage due to an outside influence will not be covered under warranty. Excessive force A windshield may become damaged due to excessive force being applied while performing other repairs, such as levering out the A-pillar trim or removing a rear view mirror. If the windshield is damaged as a result of excessive force being applied, warranty consideration will not be given. Stress crack Under very isolated circumstances, a stress crack may form due to a combination of glass position and heavy torsional loads on the body of the vehicle. These cracks always start from an outside edge of the glass. Most often the cracks begin at one of the corners of the windshield. Stress cracks typically occur within the first year or 10,000 miles of the vehicle's service life. Additional Notes: Only OEM BMW windshields may be considered for a warranty claim where a stress crack is the root cause. If a non BMW windshield was installed in the vehicle, any resulting damage (i.e., cracks, water leaks, etc.) will not be covered. BMW windshields can be identified by a BMW Roundel stamped on the glass in one of the lower corners. If the damage to the glass is due to an outside influence, very often the glass can be repaired as opposed to being replaced. For additional information on this repair and recommended repair kits, refer to Parts bulletin 51 09 06. WARRANTY INFORMATION Covered under the terms of the BMW New Vehicle Limited Warranty. |
Appreciate
0
|
05-03-2009, 09:10 AM | #12 | |
Major
16
Rep 1,335
Posts |
Quote:
__________________
6MT/ Sport Package/ N54/ Asa wheels/ Eibach pro kit springs/ Active autowerke Exhaust/ 35% tint
|
|
Appreciate
0
|
05-03-2009, 09:37 AM | #13 |
Second Lieutenant
6
Rep 238
Posts |
I have a small chip directly in the line of sight on our 135 and small cracks have begun radiating from it so the windshield is going to be replaced. We have full glass coverage so there won't be any out of pocket costs.
Things are being set up with an outfit called Glass America. They are ordering the windshield and necessary parts (moldings, condensation sensor for the auto wipers, etc) from the local BMW dealer so the car will have OEM, not aftermarket, parts. This all sounds hopeful, but has anyone had any experience with Glass America? Apparently depending upon the part of the country their centers are also known as Auto Glass Service. |
Appreciate
0
|
04-09-2011, 06:57 AM | #14 |
Private First Class
20
Rep 154
Posts |
Does the premium go up
I apologize to fire up a dead thread but I just didn't want to start a new discussion.
Long story short 2011 BMW 135i.Alpine white /coral.1800 miles..I was washing it yesterday and pulled the wipers up to clean the windshield, The damn wiper blade came off its metal handle and whack...the metal handle strikes back the Windshield.I have a nice Trispoke crack on the passenger side of the windshield. I have 250$ deductible coverage but was concerned about the premium shooting up if I claim it.As of now The crack seems to be manageable as its noticeable only at an angle and its on the passenger side.I wont have a choice if it spreads though.Its on a lease[barely 5 months into it]. 1.Should I inform BMW about the incident? 2.Safelite gives me 580$ estimate.Online quotes from BMW seem to be thrice that amount? I safelite any good? 3. Any safety concerns with a cracked windshield? 4.I pay ~1400$ for the 135i in insurance.Does my premium go up If i claim it? |
Appreciate
0
|
04-09-2011, 07:16 AM | #15 | |
Colonel
1092
Rep 2,016
Posts |
Quote:
In MA, there was no cost for a replacement (no deductible, no change in premiums, etc), but that was 15 years ago. Haven't had a windshield replaced since then. |
|
Appreciate
0
|
04-09-2011, 07:22 AM | #16 | |
Colonel
1092
Rep 2,016
Posts |
Quote:
I forgot to add, I contacted my insurance agent and they recommended BMW glass (car was brand new like yours). The dealer took care of the insurance claim and I didn't pay anything, or have to fill out any paperwork/claim. And my premium did not go up. I would check your policy, but it is a state law in MA that if an object damages your windshield, you are covered for this loss if you have comprehensive. |
|
Appreciate
0
|
04-11-2011, 09:11 AM | #17 | |
First Lieutenant
39
Rep 395
Posts |
Quote:
2. I just had my windshield replaced by Safelite about a month ago. They came to my house and replaced it in under 20 minutes. They delt with my insurance company and did all the paperwork. Great company. 3. Depends on the size of the crack. Cops will cite you if they can see it and it will obviously get worse the longer it goes unfixed. 4. Depends on your state laws. In FL, the insurance company must repair/replace the damage free of charge if you have comprehensive coverage. My deductable did not increase. |
|
Appreciate
0
|
04-11-2011, 06:20 PM | #18 | |
Private First Class
20
Rep 154
Posts |
Quote:
https://www.safelite.com/servlets/ProblemPartSelection |
|
Appreciate
0
|
04-12-2011, 02:56 PM | #19 | |
Major General
770
Rep 7,409
Posts |
Quote:
if you have it, pay deductible if you need to, and fix it. I am getting mine replaced under comprehensive coverage today. I am paying $200 deductible and no my insurance charges going up. |
|
Appreciate
0
|
04-12-2011, 03:05 PM | #20 |
Major General
2458
Rep 7,341
Posts |
There are only 2 windshields available for our cars and Pilkington makes them both and both come with the BMW rain sensor (if you had the option). I have the "non-OEM" Pilkington windshield on my car and it's perfectly fine. Just make sure they get the factory molding (surround piece) otherwise it just won't look right.
__________________
The views and opinions expressed in this post are those of the author and do not necessarily reflect the official policy or position of Bimmerpost.
2018 Jeep Grand Cherokee High Altitude Hemi | 2010 S4 Sold | 2010 BMW 135i Retired | 2006 Lotus Exige Sold |
Appreciate
0
|
04-30-2011, 03:30 PM | #21 |
Registered
0
Rep 4
Posts |
I just brought my 2011 128i home Thursday and this morning while washing/waxing it for the first time, opened the hood with the wipers in the up position. Needless to say, they cracked the windshield (two ~10” long cracks). I can’t help but notice that the first person who posted something about this problem wrote his comments in June, 2008. It's ridiculous that BMW has had such a basic design flaw in this car for at least 3 model years and their solution has been to bury a warning in the manual on page 121 (per Tom’s post).
At any rate, I’m going to call my insurance company on Monday and then I’m going to send a letter to BMW, asking why they have failed to correct this problem and requesting that they reimburse my insurance company for the expense of the new windshield. If they refuse to reimburse my insurance company, I will never buy another BMW and I will contact an attorney to file a class action suit. I’m not big on suing, but BMW should have corrected this design flaw a long, long time ago. Anyway, if anyone would like to join this class action suit, please send an email to me at lancetb1349@yahoo.com) with your contact information. |
Appreciate
0
|
04-30-2011, 03:32 PM | #22 |
Brigadier General
504
Rep 3,445
Posts |
Design flaw? Sorry for your pain, but this is like trying to drive into a garage with a fancy bicycle in a roof rack and bye bye fancy bike.
__________________
See my photography at http://ronscubadiver.wordpress.com
|
Appreciate
0
|
Post Reply |
Bookmarks |
Thread Tools | Search this Thread |
|
|